威格士柱塞泵

威格士液压柱塞泵靠气压供油的液压油箱，在每次启动机器后，必须等液压渍箱达到使用气压后，才能操作机械。直轴斜盘式柱塞泵分为压力供油型的自吸油型两种。压力供油型液压泵大都采用有气压的油箱，也有液压泵本身带有补油分泵向液压泵进油口提供压力油的。自吸油型液压泵的自吸油能力很强，无需外力供油。对于自吸油型柱塞泵，液压油箱内的油液不得低于油标下限，要保持足够数量的液压油。液压油的清洁度越高，液压泵的使用寿命越长。

威格士柱塞泵常见故障处理

1.柱塞泵输出流量不足或不输出油液

(1)吸入量不足。原因是吸油管路上的阻力过大或补油量不足。如泵的转速过大，油箱中液面过低，进油管漏气，滤油器堵塞等。

(2)泄漏量过大。原因是泵的间隙过大，密封不良造成。如配油盘被金属碎片、铁屑等划伤，端面漏油;变量机构中的单向阀密封面配合不好，泵体和配油盘的支承面有砂眼或研痕等。可以通过检查泵体内液压油中混杂的异物判别泵被损坏的部位。

(3)倾斜盘倾角太小，泵的排量少，这需要调节变量活塞，增加斜盘倾角。

2.中位时排油量不为零 变量式轴向柱塞泵的斜盘倾角为零时称为中位，此时泵的输出流量应为零。但有时会出现中位偏离调整机构中点的现象，在中点时仍有流量输出。其原因是控制器的位置偏离、松动或损伤，需要重新调零、紧固或更换。泵的角度维持力不够、倾斜角耳轴磨损也会产生这种现象。

3.输出流量波动 输出流量波动与很多因素有关。对变量泵可以认为是变量机构的控制不佳造成，如异物进入变量机构，在控制活塞上划出阶痕、磨痕、伤痕等，造成控制活塞运动不稳定。由于放大器能量不足或零件损坏、含有弹簧的控制活塞的阻尼器效能差，都会造成控制活塞运动不稳定。流量不稳定又往往伴随着压力波动。这类故障一般要拆开液压泵，更换受损零部件，加大阻尼，提高弹簧刚度和控制压力等。

4.输出压力异常 泵的输出压力是由负载决定的，与输入转矩近似成正比。输出压力异常有两种故障。

PVH074R02AA10B25200000100100010A

PVH74C-RF-2S-10-C25V-31

PVH074R02AA10B252000001001AA010A

PVH74C-RF-2S-11-C25V-31

PVH074R01AA10A25000000200100010A

PVH74C-RSF-1S-10-C25-31

PVH074R01AA10B25200000200100010A

PVH74C-RSF-1S-10-C25V-31

PVH074R01AA10A250000002001AA010A

PVH74C-RSF-1S-11-C25-31

PVH074R02AA10A25000000200100010A

PVH74C-RSF-2S-10-C25-31

PVH074R02AA10B25200000200100010A

PVH74C-RSF-2S-10-C25V-31

PVH074R01AA10A250000001001AB010A

PVH74QIC-RF-1S-10-C25-31

PVH074R01AA10B252000001001AB010A

PVH74QIC-RF-1S-10-C25V-31

PVH074R01AA10A250000001001AE010A

PVH74QIC-RF-1S-11-C25-31

PVH074R01AA10B252000001001AE010A

PVH74QIC-RF-1S-11-C25V-31

PVH074R02AA10A250000001001AB010A

PVH74QIC-RF-2S-10-C25-31

PVH074R02AA10B252000001001AB010A

PVH74QIC-RF-2S-10-C25V-31

PVH074R02AA10A250000001001AE010A

PVH74QIC-RF-2S-11-C25-31

PVH074R02AA10B252000001001AE010A

PVH74QIC-RF-2S-11-C25V-31

PVH074R01AB10A250000001001AB010A

PVH74QIC-RM-1S-10-C25-31

PVH074R02AB10A250000001001AE010A

PVH74QIC-RM-2S-11-C25-31

PVH074R01AA10A250000002001AB010A

PVH74QIC-RSF-1S-10-C25-31

PVH074R01AA10B252000002001AB010A

PVH74QIC-RSF-1S-10-C25V-31

PVH074R01AA10A250000002001AE010A

PVH74QIC-RSF-1S-11-C25-31

PVH074R02AA10A250000002001AB010A

PVH74QIC-RSF-2S-10-C25-31

PVH074R02AA10A250000002001AE010A

PVH74QIC-RSF-2S-11-C25-31

PVH074R01AB10A250000002001AE010A

PVH74QIC-RSM-1S-11-C25-31

VICKERS威格士PVH098柱塞泵型号.

PVH098R01AJ30A25000000100100010A

PVH98C-RF-1S-10-C25-31

PVH098R01AJ30B25200000100100010A

PVH98C-RF-1S-10-C25V-31

PVH098R01AJ30B252000001001AA010A

PVH98C-RF-1S-11-C25V-31

PVH098R02AJ30A25000000100100010A

PVH98C-RF-2S-10-C25-31

PVH098R02AJ30B25200000100100010A

PVH98C-RF-2S-10-C25V-31

PVH098R02AJ30B252000001001AA010A

PVH98C-RF-2S-11-C25V-31

PVH098R01AJ30A25000000200100010A

PVH98C-RSF-1S-10-C25-31

PVH098R01AJ30B25200000200100010A

PVH98C-RSF-1S-10-C25V-31

PVH098R02AJ30A25000000200100010A

PVH98C-RSF-2S-10-C25-31

PVH098R02AJ30B25200000200100010A

PVH98C-RSF-2S-10-C25V-31

PVH098R01AJ30A250000001001AB010A

PVH98QIC-RF-1S-10-C25-31

PVH098R01AJ30B252000001001AB010A

PVH98QIC-RF-1S-10-C25V-31

PVH098R01AJ30A250000001001AE010A

PVH98QIC-RF-1S-11-C25-31

PVH098R02AJ30B252000001001AB010A

PVH98QIC-RF-2S-10-C25V-31

PVH098R02AJ30A250000001001AE010A

PVH98QIC-RF-2S-11-C25-31

PVH098R01AD30A250000001001AB010A

PVH98QIC-RM-1S-10-C25-31

PVH098R01AD30A250000001001AE010A

PVH98QIC-RM-1S-11-C25-31

PVH098R01AJ30A250000002001AB010A

PVH98QIC-RSF-1S-10-C25-31

PVH098R01AJ30B252000002001AB010A

PVH98QIC-RSF-1S-10-C25V-31

PVH098R01AJ30A250000002001AE010A

PVH98QIC-RSF-1S-11-C25-31

PVH098R02AJ30A250000002001AB010A

PVH98QIC-RSF-2S-10-C25-31

PVH098R02AJ30A250000002001AE010A

PVH98QIC-RSF-2S-11-C25-31

PVH098R01AD30A250000002001AB010A

PVH98QIC-RSM-1S-10-C25-31

PVH098R01AD30A250000002001AE010A

PVH98QIC-RSM-1S-11-C25-31

PVH098R01AD30B252000002001AE010A

PVH98QIC-RSM-1S-11-C25V-31

PVH063R51AA10A070000002001AE010A

PVH63QIC2-RSF-1S-11-CM7-31

PVH063R01AB10A250000001001AE010A

PVH63QIC-RM-1S-11-C25-31

PVH063R01AA10D250008001001AE010A

PVH63QIC-RF-1S-11-C25T8-31

PVH063R01AA10A230000001001AE010A

PVH63QIC RF 1S 11 C23 31

PVH063R52AA10E172010001AE1AA010A

PVH63C2-RAF-2S-11-C17VT10-31

PVH063R01AA10A070000001AE1AE010A

PVH63QIC-RAF-1S-11-CM7-31

PVH063R01AA10A070000002001AE010A

PVH63QIC-RSF-1S-11-CM7-31

PVH063R02AA10A070000002001AE010A

PVH63QIC-RSF-2S-11-CM7-31

PVH063R01AA10A070000001001AA010A

PVH63C-RF-1S-11-CM7-31-CD

PVH063R08AA10B17200000100100010A

PVH63B-RF-8S-10-C17V-31-CD

PVH063R51AA10A070000001001AF010A

PVH63QPC2-RF-1S-11-CM7-31

PVH063R01AA10H002000AW1001AB010A

PVH63QIC-RF-1S-10-IC-31

PVH063R02AA10B21200000100100010A

PVH63C-RF-2S-10-C21V-31

PVH081R01AA10A150000002001AC010A

PVH81QPC-RSF-1S-10-C15-31-091

PVH081R01AA10A230000001001AA010A

PVH81C-RF-1S-11-C23-31

PVH081R01AA10A230000001001AE010A

PVH81QIC-RF-1S-11-C23-31

PVH081R01AA10A230000002001AE010A

PVH81QIC-RSF-1S-11-C23-31

PVH081R13AA10B212000AA1AV100030A

PVH81C-RAF-13S-10-C21V20B-31-0B

PVH081R01AA10A140000002001AF010A

PVH81QIC-RSF-1S-11-C14-31-CD

PVH081R01AA10A250000002001AE010A

PVH81QIC-RSF-1S-11-C25-31-CD

PVH081R02AA10B21200000100100010A

PVH81C-RF-2S-10-C21V-31

PVH106R01AJ30A230000001001AE010A

PVH106QIC-RF-1S-11-C23-31

PVH106R01AJ30A230000001001AA010A

PVH106C-RF-1S-11-C23-31

PVH106R03AJ30A250000001AD1AE010A

PVH106QIC-RAF-3S-11-C25-31

PVH106R02AJ30B232000AR1001AA010A

PVH106C-RF-2S-11-C23VB-31-224

PVH106R13AJ30A070000001AD1AE010A

PVH106QIC-RAF-13S-11-CM7-31

PVH106R02AJ30A230000001001AE010A

PVH106QIC-RF-2S-11-C23-31

PVH106R02AJ30B232000001001AA010A

PVH106C-RF-2S-11-C23V-31-181

PVH131L03AF30B252000001AJ1AA010A

PVH131C-LBF-3S-11-C25V-31

PVH141R02AF30B232000001001AA010A

PVH141C-RF-2S-11-C23V-31

PVH131L02AF30B253100001001AA010A

PVH131C-LF-2S-11-C25V31-31

PVH074L02AA10A070000001001AA010A

PVH74C-LF-2S-11-CM7-31

PVH131R16AG30B161700001AA1BL010A

PVH131QPC-RCM-16S-11-C16V17-31

PVH131L12AJ30A250000002001AE010A

PVH131QIC-LSF-12S-11-C25-31

PVH098R03AJ30B252000AL1AD8AP010A

PVH98C-RAF-3D-10-C25V-31-208

PVH074R02AA10D170005001001AA010A

PVH74C-RF-2S-11-C17T5-31

PVH131L12AF30A250000002001AB010A

PVH131QIC-LSF-12S-10-C25-31

PVH098R02AJ30A250000001AD2AA010A

PVH98C-RAF-2D-11-C25-31-036

PVH098R13AJ30A250000001AD1AA010A

PVH98C-RAF-13S-11-C25-31

PVH098L01AJ30A070000002001AA010A

PVH98C-LSF-1S-11-CM7-31

PVH074R02AA10A070000001002AF010A

PVH74QPC-RF-2D-11-CM7-31

PVH098L03AD30B252000001008AE010A

PVH98QIC-LM-3D-11-C25V-31

PVH098R13AJ30B212000001AT100010A

PVH98C-RAF-13S-10-C21V-31-031

PVH057R01AA10E252008001001AE010A

PVH57QIC-RF-1S-11-C25VT8-31

PVH074R02AA10B192000001001AA010A

PVH74C-RF-2S-11-C19V-31

PVH074L52AA10A250000001001AE010A

PVH74QIC2-LF-2S-11-C25-31

PVH098R01AJ30D250011001001AA010A

PVH98C-RF-1S-11-C25T11-31

PVH131L33AF30B252000001002AA010A

PVH131C-LF-13D-11-C25V-31-259

PVH074R13AA10B212000AA1AF100010A

PVH74C-RAF-13S-10-C21V20B-31

PVH074R0NAB10A070000001001AE010A

PVH74QIM-RM-NS-11-CM7-31

PVH098L02AJ30B252000001002AE010A

PVH98QIC-LF-2D-11-C25V-31

PVH057R01AB50A250000001001AB010A

PVH57QIC-RM-1S-10-C25-31-057

PVH057R01AB50H002000AS1001AB010A

PVH57QIC-RM-1S-10-IC-31-057

PVH131L02AJ30B252000002001AA010A

PVH131C-LSF-2S-11-C25V-31

PVH131R16AF30B252000001AM1AE010A

PVH131QIC-RCF-16S-11-C25V-17-31

PVH098L01AJ30B252000AA1001AA010A

PVH98C-LF-1S-11-C25VB-31

PVH131L02AF30B162000001AJ1AA010A

PVH131C-LBF-2S-11-C16V-31

PVH074R02AA10B252000AA1002AA010A

PVH74C-RF-2D-11-C25VB-31

PVH057R01AA10B252000AA2001AE010A

PVH57QIC-RSF-1S-11-C25VB-31

PVH106L02AJ30B252000001001AA010A

PVH106C-LF-2S-11-C25V-31

PVH098R02AJ70B202000001AD8AA010A

PVH98C3-RAF-2D-11-C20V-31-036

PVH074R01AA10B252000AA2001AE010A

PVH74QIC-RSF-1S-11-C25VB-31

PVH098R01AJ30B252000AA2001AE010A

PVH98QIC-RSF-1S-11-C25VB-31

PVH131R13AF30B252000AA2001AE010A

PVH131QIC-RSF-13S-11-C25VB-31

PVH057R01AA10D190012001001AE010A

PVH57QIC-RF-1S-11-C19T12-31

PVH131L29AF30B25200000100100010A

PVH131C-LF-29S-10-C25V-31-046

PVH131R16AF30A070000001AJ1AE010A

PVH131QIC-RBF-16S-11-CM7-31

PVH098R02AJ30B072000001001AA010A

PVH98C-RF-2S-11-CM7V-31

PVH074R01AA10A140000002001AF010A

PVH74QPC-RSF-1S-11-C14-31

PVH074R01AA10A070000001001BC010A

PVH74QIC-RF-1S-11-CM7-31-115

PVH074R01AA10D250008001001AF010A

PVH74QPC-RF-1S-11-C25T8-31

PVH098R01AJ30B212000001002AA010A

PVH98C-RF-1D-11-C21V-31

PVH081L52AA10B252000001001AA010A

PVH81C2-LF-2S-11-C25V-31

PVH074R01AA10B072000001001AF010A

PVH74QPC-RF-1S-11-CM7V-31

PVH098R03AJ30A250000001AM1AA010A

PVH98C-RCF-3S-11-C25-31

PVH131L02AF30B252000001AJ1AA010A

PVH131C-LBF-2S-11-C25V-31

PVH131L12AF30B502000001AJ1AA010A

PVH131C-LBF-12S-11-C31V-31

PVH098R13AJ30B212000AA1AD100030A

PVH98C-RAF-13S-10-C21V20B-31-0B

PVH057R01AA10B072000001001AE010A

PVH57QIC-RF-1S-11-CM7V-31-CD

PVH098R02AJ30E252012001001AA010A

PVH98C-RF-2S-11-C25VT12-31-CD

PVH098L03AJ30B252000001AJ1AA010A

PVH98C-LBF-3S-11-C25V-31-CD

PVH098L02AJ30A250000001AJ2AA010A

PVH98C-LBF-2D-11-C25-31-CD

PVH141R02AF30A250000001001AE010A